Mercury, Mercury Marine, Merc , And Mercruiser Are Registered Trademarks Of Brunswick Corporation. Replace the throttle body if necessary. You will never be dissapointed with the contents of this engine workshop manual. Routine Maintenance Check the crankcase oil interval can be extended based on experience. Remove and lower the hose connecting the water inlet to the power steering cooler, or the water inlet to the heat exchanger.
Remove the combustion deposits from the firing end of the spark plug with a plug cleaner. However, individual operating habits and personal maintenance preferences can have an impact on the suggested intervals. Service Manual 31 Part Number 90-864260. Check the continuity circuit for loose or damaged connections. To avoid recurrence of the problem, contact an authorized Mercury MerCruiser dealer.
Refer to Transom Assembly sections of this manual for identification information. This manual has been written in a format that is designed to meet the needs of Mercury Marine technicians worldwide. All pages are printable, so run off what you This is the Official Service Manual that the dealers and shops use. Inspect the drive unit anodes and replace if 50 percent eroded. This includes the backs of seats, gunwales, transom, bow, decks, raised fishing seats and any rotating fishing seat;.
All diagnostic and repair procedures are covered. Check the battery charge and recharge if necessary. If the coolant level is low, contact your authorized Mercury MerCruiser dealer. Use compressed air to remove abrasives. General knowledge information is not included.
If the problem persists, contact the manufacturer regarding the correct power package. Mercury MerCruiser dealer to arrange for this test. Check the battery cable connections. You will be able to use the search function to browse the manual and print out your needed pages. It takes the stress out of docking and maneuvering in tight spaces and less-than-ideal environments. Check the steering system and the remote control for loose, missing or damaged parts. Engine will not crank over.
Appendix B Owner Service Assistance. File the electrode surfaces to restore clean, sharp edges. The test should be performed where boat is moored, using Quicksilver Reference Electrode and Test Meter. Inspect the fuel pressure regulator. Clean and tighten faulty wiring. Perform plug service only on those plugs suitable for additional service, using the following procedures: 1. Full throttle engine rpm too high 1.
Clean or repair as necessary. Only engine repairs will permanently relieve oil wet fouling. It should be clean and free of leaks. This manual has been written in a format that is designed to meet the needs of Mercury Marine technicians worldwide. Description Where Used Part No. These are located on the top of the engine underneath the engine information plate.
If purchaser cannot deliver the product to such a dealer, please notify Mercury Marine and Mercury will then arrange for the inspection and any covered repair. Mercruiser Alpha 1 parts upper gearcase drawing. Engine cranks over but will not start or starts hard 1. The oil filter should always be changed when changing the engine oil. This class will cover the Cummins Warranty Administration Manual,. This Service Manual has easy-to-read text sections with top quality diagrams and instructions. If the problem persists, drain the fuel tank and refill.
. It provides all technical repair information for rebuilding or maintaining your Mercruiser Marine. Remove any oil deposits with solvent and dry plugs thoroughly. Damage caused by submersion is not covered by the Mercury MerCruiser Limited Warranty. This manual contains service, repair procedures, assmbling, disassembling, wiring diagrams and everything you need to know. The Star label identifies that these engines meet the California Air Resources Board's Sterndrive and Inboard marine engine 2007 and later exhaust emission standards.